Metro operator fined £1.5m after employee is electrocuted
Tyne and Wear Metro operator Nexus has been fined £1.5m after pleading guilty to an offence under the Health and Safety at Work etc. Act 1974, for failing to ensure the safety of staff, following the death of a Nexus employee at the company’s South Gosforth depot in July 2014.
John Bell died while working at height carrying out maintenance work on high-voltage overhead cables. He was electrocuted after making contact with a wire he believed to be isolated from the power supply, but, due to the incorrect installation of equipment, it was in fact live.
In its investigation, industry regulator the Office of Rail and Road (ORR) found safety-critical procedures were ignored and some continued for a substantial period after Mr Bell’s death. This included failures to allow work to be carried out without the appropriate instructions for staff to prevent injury; work being undertaken without the required safety critical permits; and serious inadequacies in policy documents covering ‘live line working’, which failed to include a requirement for staff to test all electrical wires before carrying out work.
If work is considered to be high risk – like working at height, or with electricity – strict controls are required. Work must be carried out against previously agreed safety procedures, known as a ‘permit-to-work' system. A permit to work is a formal written system used to control certain types of work that are potentially hazardous.
ORR found lessons were not learned over a number of years and problems persisted despite the death of Mr Bell, putting people at risk for a substantial period thereafter.
Sentence was passed by His Honour Judge Spragg at Newcastle-Upon-Tyne Crown Court, following ORR’s prosecution.
Ian Prosser CBE, HM Chief Inspector of Railways at ORR, said:
“Nexus’ working practices were poor and continued so for a long time. This meant Nexus did not have the right measures in place to assess whether the Metro was being maintained safely. It is a fundamental safety requirement to test electrical equipment before any work takes place, but the failure to review and monitor safety critical systems meant that lessons were not learned.
“This sadly contributed to the events which caused the death of Mr Bell. Our thoughts remain with the family and friends of Mr Bell and I hope this result brings them some peace.”
Nexus agreed the failures involved were a significant cause of the death of Mr Bell.
In his remarks, His Honour Judge Spragg said the case was an avoidable tragedy of a much-loved man and that Nexus should have prevented such a state of affairs from arising and continuing.
related content
